service checklist xls

DSN_KLR650
Post Reply
klrider99
Posts: 21
Joined: Mon Mar 10, 2003 8:28 pm

popping on decell.......

Post by klrider99 » Tue Aug 25, 2009 10:16 am

Dulcinea, my A13 KLR650 has recently started popping on decelleration. It hasn't done this in years, not since I set the idle screw two turns out. A week ago I set it to three turns out and the popping stopped, but has started popping again after 50 or so miles. I also cleaned out the carb and emptied the IMS tank and refilled it with fresh fuel. Anyone know what might be causing the popping? Would a leaky diaphragm do this? The bike runs well otherwise and gives ~52 mpg, uses no oil. I am thinking maybe this junk alcohol gas may be the culprit? My DR350SEX started popping on decell a month ago, too. ??? Anyone else experience this? It's just annoying and the bike seems to run a little hotter. Thanks.

guymanbro
Posts: 366
Joined: Tue Dec 04, 2001 11:54 pm

popping on decell.......

Post by guymanbro » Tue Aug 25, 2009 4:21 pm

--- In DSN_KLR650@yahoogroups.com, "klrider99" wrote:
> > Dulcinea, my A13 KLR650 has recently started popping on decelleration. It hasn't done this in years, not since I set the idle screw two turns out. A week ago I set it to three turns out and the popping stopped, but has started popping again after 50 or so miles. I also cleaned out the carb and emptied the IMS tank and refilled it with fresh fuel. > > Anyone know what might be causing the popping? Would a leaky diaphragm do this? The bike runs well otherwise and gives ~52 mpg, uses no oil. >
It could be a leak in the exhaust system, most likely at the header flange, but could be a mid-pipe joint as well. There is a copper crush gasket at the exhaust flange that has been the culprit for others. On an A13, it's likely a good choice to replace it. Sometimes, just tightening the nuts on that flange will stop the problem. A leaky diaphragm would probably cause other symptoms besides just popping, though anything is possible. da Vermonster

dooden
Posts: 3355
Joined: Sat Dec 15, 2001 3:37 pm

popping on decell.......

Post by dooden » Tue Aug 25, 2009 10:49 pm

Seafoam. Dooden A15 Green Ape
--- In DSN_KLR650@yahoogroups.com, "klrider99" wrote: > > Dulcinea, my A13 KLR650 has recently started popping on decelleration. It hasn't done this in years, not since I set the idle screw two turns out. A week ago I set it to three turns out and the popping stopped, but has started popping again after 50 or so miles. I also cleaned out the carb and emptied the IMS tank and refilled it with fresh fuel. > > Anyone know what might be causing the popping? Would a leaky diaphragm do this? The bike runs well otherwise and gives ~52 mpg, uses no oil. > > I am thinking maybe this junk alcohol gas may be the culprit? My DR350SEX started popping on decell a month ago, too. ??? Anyone else experience this? It's just annoying and the bike seems to run a little hotter. > > Thanks. >

Mike Frey
Posts: 833
Joined: Sun Apr 04, 2004 10:53 am

popping on decell.......

Post by Mike Frey » Tue Aug 25, 2009 11:00 pm

My A18 pops during decel, it did it a little bit last year, more so this year. Nothing that worries me, but something I notice. People riding with me can hear it, too. I use Seafoam liberally already. Bike runs fine otherwise, and gas mileage is the same. No apparent power loss. Mike
----- Original Message ----- From: Dooden To: DSN_KLR650@yahoogroups.com Sent: Tuesday, August 25, 2009 11:48 PM Subject: [DSN_KLR650] Re: Popping on decell....... Seafoam. Dooden A15 Green Ape --- In DSN_KLR650@yahoogroups.com, "klrider99" wrote: > > Dulcinea, my A13 KLR650 has recently started popping on > decelleration. It hasn't done this in years, not since I > set the idle screw two turns out. A week ago I set it to > three turns out and the popping stopped, but has started > popping again after 50 or so miles. I also cleaned out the > carb and emptied the IMS tank and refilled it with fresh > fuel. > > Anyone know what might be causing the popping? Would a > leaky diaphragm do this? The bike runs well otherwise and > gives ~52 mpg, uses no oil. > > I am thinking maybe this junk alcohol gas may be the > culprit? My DR350SEX started popping on decell a month > ago, too. ??? Anyone else experience this? It's just > annoying and the bike seems to run a little hotter. > > Thanks. >

Eric J Foster
Posts: 121
Joined: Fri May 11, 2001 5:54 am

popping on decell.......

Post by Eric J Foster » Wed Aug 26, 2009 7:30 am

What the others said, check for an air leak in the exhaust tract, make sure the pilot circuit is absolutely spotless. Even make sure the air filter is clean and not overoiled, though I would doubt that issue is causing this. Once the easy stuff is done, check the valve adjustment. It'd be my next guess. E -- Experience is what you gain immediately after you really need it. http://wwsw.the912project.com/

klrider99
Posts: 21
Joined: Mon Mar 10, 2003 8:28 pm

popping on decell.......

Post by klrider99 » Wed Aug 26, 2009 2:02 pm

Thanks much for the recommendations, guys. Valves are good, just did them in July. Carb is whistle clean. I will check all the exhaust fasteners and then order a new diaphragm for the air valve. Dulcinea has 54K miles on her and probably needs a little help there. Cheers, Pat

bikerlbm
Posts: 2
Joined: Wed Aug 26, 2009 7:54 pm

service checklist xls

Post by bikerlbm » Wed Aug 26, 2009 8:54 pm

Does anyone have a maintenance/service checklist in spreadsheet format? If so would you send a private e-mail. I have an 09 due for its 1000 mile and would like to have the service person provide written records of tolerances, etc as they check off and complete the items on the required maintence list for that interval. Replies appreciated.

Post Reply

Who is online

Users browsing this forum: No registered users and 24 guests