teflon tape on klr bolts/screws?

[david zawadzki]

Hello folks, Hope everyone is doing well. Fixing up my stolen bike and I just put back the stock muffler on it. Before it was a straight pipe. Way too loud but I never noticed any smoke coming out in the few rides I did with it. I purchased a used stock muffler, installed it and it was blowing out smoke today. It did not smell like oil. I know what burning oil smells like. I'm guessing its coolant. Smells like chemicals. The color is hard to tell. Not sure if it's white or blue or gray. Is there a way to do a test? Should I drain the oil and smell the oil? If it is burning coolant what needs to be replaced? Bike has 12k on it. Valves? They sound good. No clicking. I didn't know how to check them but will if you think that's it. Thanks! David Z mobile: 646.267.1109 poisonpartyband.com

[david zawadzki]

Oh I forgot to mention. In September the bike idled fine with just a pipe running out of the engine (no muffler) Yesterday after replacing it with the stock muffler the bike would run well only with the choke on. It did sit without being started for about 4 months. Not sure if that matters much. Installed a new battery. David Z mobile: 646.267.1109 poisonpartyband.com

> On Mar 25, 2017, at 9:39 PM, David Zawadzki wrote: > > Hello folks, > > Hope everyone is doing well. > > Fixing up my stolen bike and I just put back the stock muffler on it. Before it was a straight pipe. Way too loud but I never noticed any smoke coming out in the few rides I did with it. I purchased a used stock muffler, installed it and it was blowing out smoke today. It did not smell like oil. I know what burning oil smells like. I'm guessing its coolant. Smells like chemicals. The color is hard to tell. Not sure if it's white or blue or gray. > > Is there a way to do a test? Should I drain the oil and smell the oil? If it is burning coolant what needs to be replaced? > > Bike has 12k on it. Valves? They sound good. No clicking. I didn't know how to check them but will if you think that's it. > > Thanks! > > David Z > mobile: 646.267.1109 > poisonpartyband.com > >

[Michael Martin]

In the absence of a pressure tester, I devised a test set-up as written up here: http://koczarski.com/mmartin/Pressure.htm It works the same as what Jeff described except it depends on the pressure cap having a good seal. According to my Clymer manual covering 1987-2006 models, the radiator cap relief pressure spec is 13.5-17.8 psi., so adjust the test pressure accordingly. Mike Martin [b]From:[/b] "salinej1@... [DSN_KLR650]" DSN_KLR650@yahoogroups.com> [b]To:[/b] fordavidz@... [b]Cc:[/b] DSN_klr650@yahoogroups.com [b]Sent:[/b] Saturday, March 25, 2017 11:22 PM Subject: Fw: [DSN_KLR650] Re: 2007 Klr 650 burning something   ----Oh I forgot to mention. In September the bike idled fine with just a pipe running out of the engine (no muffler) Yesterday after replacing it with the stock muffler the bike would run well only with the choke on. It did sit without being started for about 4 months. Not sure if that matters much. Installed a new battery. David Z mobile: 646.267.1109 poisonpartyband.com

> On Mar 25, 2017, at 9:39 PM, David Zawadzki

wrote:

> > Hello folks, > > Hope everyone is doing well. > > Fixing up my stolen bike and I just put back the stock muffler on it.

Before it was a straight pipe. Way too loud but I never noticed any smoke coming out in the few rides I did with it. I purchased a used stock muffler, installed it and it was blowing out smoke today. It did not smell like oil. I know what burning oil smells like. I'm guessing its coolant. Smells like chemicals. The color is hard to tell. Not sure if it's white or blue or gray.

> > Is there a way to do a test? Should I drain the oil and smell the oil?

If it is burning coolant what needs to be replaced?

> > Bike has 12k on it. Valves? They sound good. No clicking. I didn't

know how to check them but will if you think that's it.

> > Thanks! > > David Z > mobile: 646.267.1109 > poisonpartyband.com

<><><><><><><> <><><><><><><> David, The won't idle without choke after sitting for 4 months is probably a clogged pilot jet. If you didn't drain fuel from the carb four months ago the fuel probably caused the issue. Clean the jet and it will probably idle fine. For the chemical smell from the exhaust... check the coolant level in the reservoir and also with the engine cold remove the radiator cap and make sure the radiator is full. Then take a ride of maybe 20 miles and monitor the temp gauge. Also monitor the smell to see if it burns off. Maybe the smell is from the previous bike and contaminates inside the muffler. Let the engine get cold and then again check the coolant level in the reservoir and radiator. If the level changed (lowered) it suggests a coolant leak. If the level remains the same maybe take another test ride of 40 miles and check again. Do this a couple of times to see if the smell is coolant. No change in the coolant level suggests the cooling system is leak free. If the coolant level goes down and you don't see any external leaks and the smell continues it suggests the coolant is leaking at the head gasket. It could be a cracked head too but you won't know until you inspect the head. Most owners don't have the equipment to pressure check the coolant system. A hand pump is mounted to the radiator via a special adapter that simulates a radiator cap. Pressure is applied to the coolant system up to maybe 15 psi. The gauge on the pump is monitored for a while to see if it drops. If the seal is good at the radiator a pressure drop (no external leaks) suggests an internal issue like a head gasket leaking or a cracked head. You can buy a coolant system pressure tester at Harbor Freight but I don't know if it has an adapter that fits the KLR radiator. Best, Jeff Saline The Beautiful Black Hills of South Dakota 75 R90/6, 03 KLR650 . . . . . . . __________________________________________________________ Sasha Obama's IQ Will Make You Laugh Out Loud likeitviral.com http://thirdpartyoffers.juno.com/TGL314 ... 5ccst04vuc #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721 -- #ygrps-yiv-628032444yiv5694463721ygrp-mkp { border:1px solid #d8d8d8;font-family:Arial;margin:10px 0;padding:0 10px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-mkp hr { border:1px solid #d8d8d8;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-mkp #ygrps-yiv-628032444yiv5694463721hd { color:#628c2a;font-size:85%;font-weight:700;line-height:122%;margin:10px 0;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-mkp #ygrps-yiv-628032444yiv5694463721ads { margin-bottom:10px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-mkp .ygrps-yiv-628032444yiv5694463721ad { padding:0 0;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-mkp .ygrps-yiv-628032444yiv5694463721ad p { margin:0;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-mkp .ygrps-yiv-628032444yiv5694463721ad a { color:#0000ff;text-decoration:none;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-sponsor #ygrps-yiv-628032444yiv5694463721ygrp-lc { font-family:Arial;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-sponsor #ygrps-yiv-628032444yiv5694463721ygrp-lc #ygrps-yiv-628032444yiv5694463721hd { margin:10px 0px;font-weight:700;font-size:78%;line-height:122%;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-sponsor #ygrps-yiv-628032444yiv5694463721ygrp-lc .ygrps-yiv-628032444yiv5694463721ad { margin-bottom:10px;padding:0 0;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721actions { font-family:Verdana;font-size:11px;padding:10px 0;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721activity { background-color:#e0ecee;float:left;font-family:Verdana;font-size:10px;padding:10px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721activity span { font-weight:700;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721activity span:first-child { text-transform:uppercase;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721activity span a { color:#5085b6;text-decoration:none;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721activity span span { color:#ff7900;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721activity span .ygrps-yiv-628032444yiv5694463721underline { text-decoration:underline;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 .ygrps-yiv-628032444yiv5694463721attach { clear:both;display:table;font-family:Arial;font-size:12px;padding:10px 0;width:400px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 .ygrps-yiv-628032444yiv5694463721attach div a { text-decoration:none;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 .ygrps-yiv-628032444yiv5694463721attach img { border:none;padding-right:5px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 .ygrps-yiv-628032444yiv5694463721attach label { display:block;margin-bottom:5px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 .ygrps-yiv-628032444yiv5694463721attach label a { text-decoration:none;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 blockquote { margin:0 0 0 4px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 .ygrps-yiv-628032444yiv5694463721bold { font-family:Arial;font-size:13px;font-weight:700;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 .ygrps-yiv-628032444yiv5694463721bold a { text-decoration:none;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 dd.ygrps-yiv-628032444yiv5694463721last p a { font-family:Verdana;font-weight:700;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 dd.ygrps-yiv-628032444yiv5694463721last p span { margin-right:10px;font-family:Verdana;font-weight:700;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 dd.ygrps-yiv-628032444yiv5694463721last p span.ygrps-yiv-628032444yiv5694463721yshortcuts { margin-right:0;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 div.ygrps-yiv-628032444yiv5694463721attach-table div div a { text-decoration:none;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 div.ygrps-yiv-628032444yiv5694463721attach-table { width:400px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 div.ygrps-yiv-628032444yiv5694463721file-title a, #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 div.ygrps-yiv-628032444yiv5694463721file-title a:active, #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 div.ygrps-yiv-628032444yiv5694463721file-title a:hover, #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 div.ygrps-yiv-628032444yiv5694463721file-title a:visited { text-decoration:none;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 div.ygrps-yiv-628032444yiv5694463721photo-title a, #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 div.ygrps-yiv-628032444yiv5694463721photo-title a:active, #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 div.ygrps-yiv-628032444yiv5694463721photo-title a:hover, #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 div.ygrps-yiv-628032444yiv5694463721photo-title a:visited { text-decoration:none;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 div#ygrps-yiv-628032444yiv5694463721ygrp-mlmsg #ygrps-yiv-628032444yiv5694463721ygrp-msg p a span.ygrps-yiv-628032444yiv5694463721yshortcuts { font-family:Verdana;font-size:10px;font-weight:normal;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 .ygrps-yiv-628032444yiv5694463721green { color:#628c2a;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 .ygrps-yiv-628032444yiv5694463721MsoNormal { margin:0 0 0 0;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 o { font-size:0;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721photos div { float:left;width:72px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721photos div div { border:1px solid #666666;height:62px;overflow:hidden;width:62px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721photos div label { color:#666666;font-size:10px;overflow:hidden;text-align:center;white-space:nowrap;width:64px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721reco-category { font-size:77%;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721reco-desc { font-size:77%;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 .ygrps-yiv-628032444yiv5694463721replbq { margin:4px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-actbar div a:first-child { margin-right:2px;padding-right:5px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-mlmsg { font-size:13px;font-family:Arial, helvetica, clean, sans-serif;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-mlmsg table { font-size:inherit;font:100%;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-mlmsg select, #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 input, #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 textarea { font:99% Arial, Helvetica, clean, sans-serif;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-mlmsg pre, #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 code { font:115% monospace;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-mlmsg * { line-height:1.22em;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-mlmsg #ygrps-yiv-628032444yiv5694463721logo { padding-bottom:10px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-msg p a { font-family:Verdana;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-msg p#ygrps-yiv-628032444yiv5694463721attach-count span { color:#1E66AE;font-weight:700;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-reco #ygrps-yiv-628032444yiv5694463721reco-head { color:#ff7900;font-weight:700;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-reco { margin-bottom:20px;padding:0px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-sponsor #ygrps-yiv-628032444yiv5694463721ov li a { font-size:130%;text-decoration:none;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-sponsor #ygrps-yiv-628032444yiv5694463721ov li { font-size:77%;list-style-type:square;padding:6px 0;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-sponsor #ygrps-yiv-628032444yiv5694463721ov ul { margin:0;padding:0 0 0 8px;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-text { font-family:Georgia;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-text p { margin:0 0 1em 0;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-text tt { font-size:120%;} #ygrps-yiv-628032444 #ygrps-yiv-628032444yiv5694463721 #ygrps-yiv-628032444yiv5694463721ygrp-vital ul li:last-child { border-right:none !important;} #ygrps-yiv-628032444

[david zawadzki]

Thanks for that.  So I ran the bike for 20 minutes today and the smoke kept coming out but got less and less towards the end. I decided to take off the muffler I bought (original klr650 pre 2008) to see if it still smokes.  To my surprise it did not.  I checked the oil And it looked  good in the little oil window.  Not white, just regular.  If coolant got into the engine would it turn the oil milky same way water does? I shook the muffler and there is something rattling inside.  A piece of metal and hard cloth fell out.  Maybe that's what's burning inside.  Any ideas on how to get them out? Or burn em out?   Have a safe week.  David Zmobile: 646.267.1109poisonpartyband.com

On Mar 26, 2017, at 10:31 AM, Michael Martin wrote:

In the absence of a pressure tester, I devised a test set-up as written up here: http://koczarski.com/mmartin/Pressure.htm It works the same as what Jeff described except it depends on the pressure cap having a good seal. According to my Clymer manual covering 1987-2006 models, the radiator cap relief pressure spec is 13.5-17.8 psi., so adjust the test pressure accordingly. Mike Martin [b]From:[/b] "salinej1@... [DSN_KLR650]" DSN_KLR650@yahoogroups.com> [b]To:[/b] fordavidz@... [b]Cc:[/b] DSN_klr650@yahoogroups.com [b]Sent:[/b] Saturday, March 25, 2017 11:22 PM Subject: Fw: [DSN_KLR650] Re: 2007 Klr 650 burning something   ----Oh I forgot to mention. In September the bike idled fine with just a pipe running out of the engine (no muffler) Yesterday after replacing it with the stock muffler the bike would run well only with the choke on. It did sit without being started for about 4 months. Not sure if that matters much. Installed a new battery. David Z mobile: 646.267.1109 poisonpartyband.com > On Mar 25, 2017, at 9:39 PM, David Zawadzki wrote: > > Hello folks, > > Hope everyone is doing well. > > Fixing up my stolen bike and I just put back the stock muffler on it. Before it was a straight pipe. Way too loud but I never noticed any smoke coming out in the few rides I did with it. I purchased a used stock muffler, installed it and it was blowing out smoke today. It did not smell like oil. I know what burning oil smells like. I'm guessing its coolant. Smells like chemicals. The color is hard to tell. Not sure if it's white or blue or gray. > > Is there a way to do a test? Should I drain the oil and smell the oil? If it is burning coolant what needs to be replaced? > > Bike has 12k on it. Valves? They sound good. No clicking. I didn't know how to check them but will if you think that's it. > > Thanks! > > David Z > mobile: 646.267.1109 > poisonpartyband.com <><><><><><><> <><><><><><><> David, The won't idle without choke after sitting for 4 months is probably a clogged pilot jet. If you didn't drain fuel from the carb four months ago the fuel probably caused the issue. Clean the jet and it will probably idle fine. For the chemical smell from the exhaust... check the coolant level in the reservoir and also with the engine cold remove the radiator cap and make sure the radiator is full. Then take a ride of maybe 20 miles and monitor the temp gauge. Also monitor the smell to see if it burns off. Maybe the smell is from the previous bike and contaminates inside the muffler. Let the engine get cold and then again check the coolant level in the reservoir and radiator. If the level changed (lowered) it suggests a coolant leak. If the level remains the same maybe take another test ride of 40 miles and check again. Do this a couple of times to see if the smell is coolant. No change in the coolant level suggests the cooling system is leak free. If the coolant level goes down and you don't see any external leaks and the smell continues it suggests the coolant is leaking at the head gasket. It could be a cracked head too but you won't know until you inspect the head. Most owners don't have the equipment to pressure check the coolant system. A hand pump is mounted to the radiator via a special adapter that simulates a radiator cap. Pressure is applied to the coolant system up to maybe 15 psi. The gauge on the pump is monitored for a while to see if it drops. If the seal is good at the radiator a pressure drop (no external leaks) suggests an internal issue like a head gasket leaking or a cracked head. You can buy a coolant system pressure tester at Harbor Freight but I don't know if it has an adapter that fits the KLR radiator. Best, Jeff Saline The Beautiful Black Hills of South Dakota 75 R90/6, 03 KLR650 . . . . . . . __________________________________________________________ Sasha Obama's IQ Will Make You Laugh Out Loud likeitviral.com http://thirdpartyoffers.juno.com/TGL3141/58d7339ba5732339b75ccst04vuc

[jeffsaline]

On Sun, 26 Mar 2017 23:04:29 -0400 David Zawadzki writes: Thanks for that.  So I ran the bike for 20 minutes today and the smoke kept coming out but got less and less towards the end. I decided to take off the muffler I bought (original klr650 pre 2008) to see if it still smokes.  To my surprise it did not.  I checked the oil And it looked  good in the little oil window.  Not white, just regular.  If coolant got into the engine would it turn the oil milky same way water does? I shook the muffler and there is something rattling inside.  A piece of metal and hard cloth fell out.  Maybe that's what's burning inside.  Any ideas on how to get them out? Or burn em out?    Have a safe week.   David Z mobile: 646.267.1109 poisonpartyband.com <><><><><><><><> <><><><><><><><>   David,   Maybe someone had an oily rag/paper towel in the head or header and forgot to take it out when the muffler was removed/installed and it has now moved into the muffler.   A rattle sound might be a broken piece of exhaust inside the muffler.  I've heard of them rotting after a while and breaking off.  Usually it doesn't cause any issue but sometimes it will slow the exhaust gasses from exiting and limit engine performance.  If the noise is of real concern maybe cut an opening in the back side of the muffler with a cutoff wheel and inspect the inside.  Then weld the piece back in place and finally paint with Bar-B-Que or other high heat type paint.  You might also be able to insert a longish bar/rod in the muffler exit and see if the innards are tight/secure.  Might not want to work it too hard though.   Coolant in the engine will normally turn the oil milky but coolant in the engine usually can't be smelled until the engine seizes from lack of lubrication.   My guess is the new to you muffler is the entire issue.   Best, Jeff Saline The Beautiful Black Hills of South Dakota 75 R90/6, 03 KLR650   . . . . . . . . ____________________________________________________________ [b]Affordable Wireless Plans[/b] Set up is easy. Get online in minutes. Starting at only $14.95 per month! www.netzero.net

[Norm Keller]

I haven't lost a bolt or screw in years. Not planning your solution, just put them in with Loctite, silicone gasket maker, or elastic stop nuts, as indicated.

[david zawadzki]

Hi, I drilled out the back of the muffler and removed the tweety. There is still something in there that keeps smoking.Do you gus have any experience with burning out the muffler?https://www.youtube.com/watch? v=F51BC8-wZ9I https://www.youtube.com/watch? v=CW3DfP6WXf0 Can I spray some carb cleaner in there and light the sucker up lol? Do I need to spray some air in there? Thanks,David

On Sun, Mar 26, 2017 at 11:22 PM, wrote: [u][/u] On Sun, 26 Mar 2017 23:04:29 -0400 David Zawadzki writes: Thanks for that. So I ran the bike for 20 minutes today and the smoke kept coming out but got less and less towards the end. I decided to take off the muffler I bought (original klr650 pre 2008) to see if it still smokes. To my surprise it did not. I checked the oil And it looked good in the little oil window. Not white, just regular. If coolant got into the engine would it turn the oil milky same way water does? I shook the muffler and there is something rattling inside. A piece of metal and hard cloth fell out. Maybe that's what's burning inside. Any ideas on how to get them out? Or burn em out? Have a safe week. David Z mobile: 646.267.1109 poisonpartyband.com <><><><><><><><> <><><><><><><><> David, Maybe someone had an oily rag/paper towel in the head or header and forgot to take it out when the muffler was removed/installed and it has now moved into the muffler. A rattle sound might be a broken piece of exhaust inside the muffler. I've heard of them rotting after a while and breaking off. Usually it doesn't cause any issue but sometimes it will slow the exhaust gasses from exiting and limit engine performance. If the noise is of real concern maybe cut an opening in the back side of the muffler with a cutoff wheel and inspect the inside. Then weld the piece back in place and finally paint with Bar-B-Que or other high heat type paint. You might also be able to insert a longish bar/rod in the muffler exit and see if the innards are tight/secure. Might not want to work it too hard though. Coolant in the engine will normally turn the oil milky but coolant in the engine usually can't be smelled until the engine seizes from lack of lubrication. My guess is the new to you muffler is the entire issue. Best, Jeff Saline The Beautiful Black Hills of South Dakota 75 R90/6, 03 KLR650 . . . . . . . . ______________________________ ______________________________ [b]Affordable Wireless Plans[/b] Set up is easy. Get online in minutes. Starting at only $14.95 per month! www.netzero.net

-- David Z mobile: 646-267-1109 poisonpartyband.com

[Mark]

ps. I sure by my wordiness, that Whenever I get a product I like, and company that backs it, Everyone Hears about it. LOLOL On Tuesday, April 11, 2017 10:52 AM, "david zawadzki fordavidz@... [DSN_KLR650]" DSN_KLR650@yahoogroups.com> wrote:   Hi, I drilled out the back of the muffler and removed the tweety. There is still something in there that keeps smoking.Do you gus have any experience with burning out the muffler?https://www.youtube.com/watch? v=F51BC8-wZ9I https://www.youtube.com/watch? v=CW3DfP6WXf0 Can I spray some carb cleaner in there and light the sucker up lol? Do I need to spray some air in there? Thanks,David On Sun, Mar 26, 2017 at 11:22 PM, wrote:

[u][/u] On Sun, 26 Mar 2017 23:04:29 -0400 David Zawadzki writes: Thanks for that.  So I ran the bike for 20 minutes today and the smoke kept coming out but got less and less towards the end. I decided to take off the muffler I bought (original klr650 pre 2008) to see if it still smokes.  To my surprise it did not.  I checked the oil And it looked  good in the little oil window.  Not white, just regular.  If coolant got into the engine would it turn the oil milky same way water does? I shook the muffler and there is something rattling inside.  A piece of metal and hard cloth fell out.  Maybe that's what's burning inside.  Any ideas on how to get them out? Or burn em out?    Have a safe week.   David Z mobile: 646.267.1109 poisonpartyband.com <><><><><><><><> <><><><><><><><>   David,   Maybe someone had an oily rag/paper towel in the head or header and forgot to take it out when the muffler was removed/installed and it has now moved into the muffler.   A rattle sound might be a broken piece of exhaust inside the muffler.  I've heard of them rotting after a while and breaking off.  Usually it doesn't cause any issue but sometimes it will slow the exhaust gasses from exiting and limit engine performance.  If the noise is of real concern maybe cut an opening in the back side of the muffler with a cutoff wheel and inspect the inside.  Then weld the piece back in place and finally paint with Bar-B-Que or other high heat type paint.  You might also be able to insert a longish bar/rod in the muffler exit and see if the innards are tight/secure.  Might not want to work it too hard though.   Coolant in the engine will normally turn the oil milky but coolant in the engine usually can't be smelled until the engine seizes from lack of lubrication.   My guess is the new to you muffler is the entire issue.   Best, Jeff Saline The Beautiful Black Hills of South Dakota 75 R90/6, 03 KLR650   . . . . . . . . ______________________________ ______________________________ [b]Affordable Wireless Plans[/b] Set up is easy. Get online in minutes. Starting at only $14.95 per month! www.netzero.net

-- David Z mobile: 646-267-1109 poisonpartyband.com #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267 -- #ygrps-yiv-2004330957yiv0165662267ygrp-mkp { border:1px solid #d8d8d8;font-family:Arial;margin:10px 0;padding:0 10px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-mkp hr { border:1px solid #d8d8d8;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-mkp #ygrps-yiv-2004330957yiv0165662267hd { color:#628c2a;font-size:85%;font-weight:700;line-height:122%;margin:10px 0;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-mkp #ygrps-yiv-2004330957yiv0165662267ads { margin-bottom:10px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-mkp .ygrps-yiv-2004330957yiv0165662267ad { padding:0 0;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-mkp .ygrps-yiv-2004330957yiv0165662267ad p { margin:0;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-mkp .ygrps-yiv-2004330957yiv0165662267ad a { color:#0000ff;text-decoration:none;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-sponsor #ygrps-yiv-2004330957yiv0165662267ygrp-lc { font-family:Arial;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-sponsor #ygrps-yiv-2004330957yiv0165662267ygrp-lc #ygrps-yiv-2004330957yiv0165662267hd { margin:10px 0px;font-weight:700;font-size:78%;line-height:122%;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-sponsor #ygrps-yiv-2004330957yiv0165662267ygrp-lc .ygrps-yiv-2004330957yiv0165662267ad { margin-bottom:10px;padding:0 0;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267actions { font-family:Verdana;font-size:11px;padding:10px 0;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267activity { background-color:#e0ecee;float:left;font-family:Verdana;font-size:10px;padding:10px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267activity span { font-weight:700;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267activity span:first-child { text-transform:uppercase;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267activity span a { color:#5085b6;text-decoration:none;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267activity span span { color:#ff7900;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267activity span .ygrps-yiv-2004330957yiv0165662267underline { text-decoration:underline;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 .ygrps-yiv-2004330957yiv0165662267attach { clear:both;display:table;font-family:Arial;font-size:12px;padding:10px 0;width:400px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 .ygrps-yiv-2004330957yiv0165662267attach div a { text-decoration:none;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 .ygrps-yiv-2004330957yiv0165662267attach img { border:none;padding-right:5px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 .ygrps-yiv-2004330957yiv0165662267attach label { display:block;margin-bottom:5px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 .ygrps-yiv-2004330957yiv0165662267attach label a { text-decoration:none;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 blockquote { margin:0 0 0 4px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 .ygrps-yiv-2004330957yiv0165662267bold { font-family:Arial;font-size:13px;font-weight:700;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 .ygrps-yiv-2004330957yiv0165662267bold a { text-decoration:none;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 dd.ygrps-yiv-2004330957yiv0165662267last p a { font-family:Verdana;font-weight:700;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 dd.ygrps-yiv-2004330957yiv0165662267last p span { margin-right:10px;font-family:Verdana;font-weight:700;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 dd.ygrps-yiv-2004330957yiv0165662267last p span.ygrps-yiv-2004330957yiv0165662267yshortcuts { margin-right:0;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 div.ygrps-yiv-2004330957yiv0165662267attach-table div div a { text-decoration:none;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 div.ygrps-yiv-2004330957yiv0165662267attach-table { width:400px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 div.ygrps-yiv-2004330957yiv0165662267file-title a, #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 div.ygrps-yiv-2004330957yiv0165662267file-title a:active, #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 div.ygrps-yiv-2004330957yiv0165662267file-title a:hover, #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 div.ygrps-yiv-2004330957yiv0165662267file-title a:visited { text-decoration:none;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 div.ygrps-yiv-2004330957yiv0165662267photo-title a, #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 div.ygrps-yiv-2004330957yiv0165662267photo-title a:active, #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 div.ygrps-yiv-2004330957yiv0165662267photo-title a:hover, #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 div.ygrps-yiv-2004330957yiv0165662267photo-title a:visited { text-decoration:none;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 div#ygrps-yiv-2004330957yiv0165662267ygrp-mlmsg #ygrps-yiv-2004330957yiv0165662267ygrp-msg p a span.ygrps-yiv-2004330957yiv0165662267yshortcuts { font-family:Verdana;font-size:10px;font-weight:normal;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 .ygrps-yiv-2004330957yiv0165662267green { color:#628c2a;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 .ygrps-yiv-2004330957yiv0165662267MsoNormal { margin:0 0 0 0;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 o { font-size:0;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267photos div { float:left;width:72px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267photos div div { border:1px solid #666666;height:62px;overflow:hidden;width:62px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267photos div label { color:#666666;font-size:10px;overflow:hidden;text-align:center;white-space:nowrap;width:64px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267reco-category { font-size:77%;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267reco-desc { font-size:77%;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 .ygrps-yiv-2004330957yiv0165662267replbq { margin:4px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-actbar div a:first-child { margin-right:2px;padding-right:5px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-mlmsg { font-size:13px;font-family:Arial, helvetica, clean, sans-serif;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-mlmsg table { font-size:inherit;font:100%;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-mlmsg select, #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 input, #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 textarea { font:99% Arial, Helvetica, clean, sans-serif;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-mlmsg pre, #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 code { font:115% monospace;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-mlmsg * { line-height:1.22em;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-mlmsg #ygrps-yiv-2004330957yiv0165662267logo { padding-bottom:10px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-msg p a { font-family:Verdana;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-msg p#ygrps-yiv-2004330957yiv0165662267attach-count span { color:#1E66AE;font-weight:700;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-reco #ygrps-yiv-2004330957yiv0165662267reco-head { color:#ff7900;font-weight:700;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-reco { margin-bottom:20px;padding:0px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-sponsor #ygrps-yiv-2004330957yiv0165662267ov li a { font-size:130%;text-decoration:none;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-sponsor #ygrps-yiv-2004330957yiv0165662267ov li { font-size:77%;list-style-type:square;padding:6px 0;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-sponsor #ygrps-yiv-2004330957yiv0165662267ov ul { margin:0;padding:0 0 0 8px;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-text { font-family:Georgia;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-text p { margin:0 0 1em 0;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-text tt { font-size:120%;} #ygrps-yiv-2004330957 #ygrps-yiv-2004330957yiv0165662267 #ygrps-yiv-2004330957yiv0165662267ygrp-vital ul li:last-child { border-right:none !important;} #ygrps-yiv-2004330957