Wilsons Sandbox

Did you mix water with your coolant ? This could accelerate the wear.

--- In DSN_klr650@y..., "Charles MacKarness" wrote: > I have notice one or two drops of coolant on the floor under my bike, > near the back of the engine, after it sits for a day or so. Riding it > hard, heating it up or running it easy seems to make no difference in > the amount or frequency of the drips. > Could there be a typical, or common, problem here? > I am thinking it may be the water pump bushing giving up the ghost, > but I am under 10k miles and bushings worn to the point of failure > does'nt seem normal. > > Rev. Chuck > :^)>+

Barnaby: Is the coolant residue on the left or right side of the bike? Is it just on the bottom of the engine or is the residue on surfaces above this? Some listers have reported heat from the exhaust system can melt the coolant reservoir tank resulting in the formation of small pinholes. John --- Barnaby Robson wrote:

> Hi > > Has anyone else experienced some coolant leakage ... > I was looking to see where it was coming from but > it seems to be coming from nowhere .. Maybe the > actual coolant tank is punctured ? I checked the > hose > at the bottom and it seems fine .... > > ... anyway .. I've still got half a tank .. > the other half is dried all over the bike.

__________________________________________________ Do You Yahoo!? Yahoo! Tax Center - online filing with TurboTax http://taxes.yahoo.com/

Hi Barnaby, My bike also had a coolant leak. I checked the hoses, etc. What I finally found was that whoever assembled the bike cross threaded the cap on the coolant resevoir. Bill A15

--- In DSN_klr650@y..., "Barnaby Robson" wrote: > Hi > > Has anyone else experienced some coolant leakage ... > I was looking to see where it was coming from but > it seems to be coming from nowhere .. Maybe the > actual coolant tank is punctured ? I checked the hose > at the bottom and it seems fine .... > > ... anyway .. I've still got half a tank .. > the other half is dried all over the bike. > > Barnaby. > > A16

Hi John, Thanks for the reply. The coolant is all over the right hand side of the bike from the bottom of the coolant tank to the skid plate, covering all areas in between. I'll check for contact with the exhaust ... Barnaby. -----Original Message----- From: John Lyon [mailto:jlyonamf@...] Sent: Friday, April 12, 2002 10:00 AM To: Klr650 (E-mail) Subject: Re: [DSN_klr650] Coolant Leak Barnaby: Is the coolant residue on the left or right side of the bike? Is it just on the bottom of the engine or is the residue on surfaces above this? Some listers have reported heat from the exhaust system can melt the coolant reservoir tank resulting in the formation of small pinholes. John --- Barnaby Robson wrote:

> Hi > > Has anyone else experienced some coolant leakage ... > I was looking to see where it was coming from but > it seems to be coming from nowhere .. Maybe the > actual coolant tank is punctured ? I checked the > hose > at the bottom and it seems fine .... > > ... anyway .. I've still got half a tank .. > the other half is dried all over the bike.

__________________________________________________ Do You Yahoo!? Yahoo! Tax Center - online filing with TurboTax http://taxes.yahoo.com/ Checkout Dual Sport News at http://www.dualsportnews.com Be part of the Adventure! Visit the KLR650 archives at http://www.listquest.com/lq/search.html?ln=klr650 Post message: DSN_klr650@yahoogroups.com Subscribe: DSN_klr650-subscribe@yahoogroups.com Unsubscribe: DSN_klr650-unsubscribe@yahoogroups.com List owner: DSN_klr650-owner@yahoogroups.com Your use of Yahoo! Groups is subject to http://docs.yahoo.com/info/terms/

Hi Barnaby, It was as simple as "re-screwing" the cap. Bill A15

--- In DSN_klr650@y..., "Barnaby Robson" wrote: > Hi Bill, > > So .. it was a simple case > of re-screwing, or did you > need a new cap ? > > Barnaby. > > > > > Subject: [DSN_klr650] Re: Coolant Leak > > My bike also had a coolant leak. I checked the hoses, etc. What I > finally found was that whoever assembled the bike cross threaded the > cap on the coolant resevoir. > Bill A15

--- In DSN_klr650@y..., "Barnaby Robson" wrote:

> Hi > > Has anyone else experienced some coolant leakage ... > I was looking to see where it was coming from but > it seems to be coming from nowhere .. Maybe the > actual coolant tank is punctured ? I checked the hose > at the bottom and it seems fine .... > > ... anyway .. I've still got half a tank .. > the other half is dried all over the bike. > > Barnaby. > > A16

OR, you could have the ever-common water seal leakage. Notice that Fred sells the seals and gaskets? Not that hard to fix, if that's what it is.... MNRon